某铅锌矿选矿生产指标的考察与分析研究
The Study of Investigation and Analysis of Lead and Zinc Mine Production Indexes
投稿时间:2017-10-13  修订日期:2017-11-20
DOI:
中文关键词:  铅锌矿  流程考察  浮选
英文关键词:Lead-zinc ore  process survey  flotation
基金项目:稀有金属冶金及功能材料开发(2017GDASCX-0110);铁钒渣酸浸液磷源除铁关键过程控制及其副产磷酸铁性能研究(2016A030313801)
作者单位E-mail
黄建平 广东省稀有金属研究所 jianpinghuangcsu@163.com 
摘要点击次数: 14
全文下载次数: 13
中文摘要:
      为了提高选矿厂的浮选效率,获得较好的铅锌浮选指标,对选矿工艺流程进行考察,分别研究了矿浆pH、回水、原矿品位对铅锌浮选指标的影响。结果表明,矿浆pH对铅浮选指标影响较小,矿浆pH过高抑制锌的浮选,铅锌粗选矿浆pH为11左右时,铅锌浮选品位与回收率均最高;原矿铅锌品位增大铅锌精矿品位与回收率均显著增大,尾矿铅锌品位基本不变;在磨矿全采用回水时造成铅浮选泡沫发粘,分选效果差,铅浮选回收率下降,铅锌浮选中矿量大,使得浮选操作难控制;经分析铅锌浮选尾矿中多为连生体,需细磨铅锌才充分单体解离。
英文摘要:
      order to improve flotation efficiency of concentrator, a better flotation index of lead-zinc ore was obtained, and the technological process of mineral processing was investigated. The influence of pH, return water and raw ore grade on the flotation index of lead-zinc ore was studied respectively. The results show that the pH has little effect on the Pb flotation index, high flotation pulp pH inhibition of zinc, lead and zinc roughing pulp pH is about 11, the lead-zinc flotation grade and recovery rate were the highest; the higher ore grade lead-zinc flotation concentrate grade and recovery rate were significantly increased, and the tailings grade basically unchanged. When the feed water is damming used, the viscosity of lead flotation froth and the separation effect is poor, the operation of lead flotation is difficult to control, and the recovery rate of lead flotation is decreased. For the coenobium in lead-zinc flotation tailings, to make full of fine grinding of Pb and Zn monomer dissociation.
查看全文  查看/发表评论  下载PDF阅读器
关闭
版权所有:矿产综合利用
地址:四川省成都市二环路南三段五号   邮政编码:610041
电话:028-85592322  Email:kczl@chinajuornal.net.cn;kczhly@163.com
技术支持:北京勤云科技发展有限公司